Dazon Raider Extreme 1100D Service Manual download pdf (Page 58)

Raider-Classic 150 (Oil-cooled&Internal Gearbox): Service Manual (single/ double-seat) EEC Version;3.0 Feb..2005

3.20.2 Transmission Case Oil

 Inspection

a) Inspect if there is oil leakage around the transmission case.

b) After the engine stops, remove the transmission case oil level bolt.

c) Observe the oil level: it is correct when the oil level is parallel with the observing hole;

When the oil level is too low, add until the oil flows from the level screw.

d) Mount the transmission case oil level bolt and the washer

 Replacement

a) Remove the transmission case oil level bolt.

b) Remove the oil drain bolt to drain the oil.

c) Mount the drain bolt and its oil seal, and fasten.

d) Supply the oil with the prescribed specification and oil level.

e) Mount the level bolt.

f) After replacing the oil, inspect for any oil leakage.

3.20.3 Transmission Case

 Transmission Case Removal

a) Remove the driven belt pulley;

Drain out the oil in the transmission case.

b) Remove the drive sprocket;

Remove the bolt, rear wheel axle comp. and fork shaft

comp.;

c) Remove the gasket and dowel pin.

 When inspecting the oil level of the transmission case, stay the vehicle on the

flat

round and kee

the bod

level.

 Supply the same kind of oil according to the prescribed brand and specification.

 Inspect if the bolt oil seal is damaged.

Drive sprocket

Bolt

Fork

Rear wheel axle

1 2 ... 53 54 55 56 57 58 59 60 61 62 63 ... 78 79

No comments

Dazon Raider Extreme 1100D Service Manual Page 58